Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Hydraulic Drive Anomaly After Pump Replacement
#1
Following the installation of a used transom (tandem hydrostatic) pump, all boom and bucket hydraulics operate normally, yet only one track motor responds—forward and right joystick motions yield movement, but only one hydraulic drive functions. Swapping solenoid plugs allows directional control but still limits operation to a single motor.

Diagnostic Pathway and Control Electronics Examination
The first diagnostic step involved accessing the machine’s service menu to view and clear stored fault codes. No new errors appeared post-replacement, but failure occurred when attempting to calibrate forward joystick movement—generating code 522447.06, defined as “Right Pump Forward Solenoid Current Out of Range – High.”
This fault sheds light on a likely electrical or control issue rather than mechanical.

Likely Culprit: Solenoid Circuit Fault
A seasoned technician points toward the malfunctioning right pump forward solenoid as the primary suspect. A common failure mode in Deere “D” series models is wiring or connector fatigue at the solenoid—often resulting from worn insulation or intermittent contact. Visually inspecting the solenoid connectors may reveal stretched or damaged wires or a connector that partially disengages.

Follow-Up Actions and Next Steps
  • Inspect solenoid wiring—especially at the connector—for signs of wear, distortions, or loose connections.
  • Repair or replace any compromised connectors and wiring.
  • Retest the hydraulic drive system post-repair, ideally with codes cleared and a fresh solenoid connector seat.

Terminology Glossary
  • Transom Pump: The skid steer’s combined hydrostatic pump and motor assembly, critical for powering travel drives.
  • Solenoid: An electrically activated valve that controls fluid flow in hydraulic systems.
  • Service Menu: A hidden diagnostic interface that displays system faults and allows certain calibration and testing functions.
  • Error Code 522447.06: Indicates a current variation in the right forward solenoid exceeding normal thresholds.
  • Calibration: A procedure aligning joystick input signals to system response thresholds.

Conclusion
When a 329D displays one-track operation after fitting a new pump, diagnosis should extend beyond the pump itself—into the realm of electrical control circuits. A specific solenoid current code often points directly to wiring or connector failure. Addressing those imperfections typically restores full bilateral drive control, making it a great example of the importance of electronics-integrated hydraulic diagnostics.
Reply


Possibly Related Threads…
Thread Author Replies Views Last Post
  Diagnosing Hydraulic Steering Issues on the BOMAG AW 90 Pneumatic Roller MikePhua 0 3 4 hours ago
Last Post: MikePhua
  Hydraulic Issues on the Kobelco SK150 LC: Troubleshooting and Solutions MikePhua 0 3 4 hours ago
Last Post: MikePhua
  Hydraulic Pressure Issues on the Hitachi ZX160 Excavator: Causes and Solutions MikePhua 0 1 4 hours ago
Last Post: MikePhua
  Uncommon Hydraulic System Failures and Troubleshooting MikePhua 0 1 5 hours ago
Last Post: MikePhua
  Diagnosing and Repairing a Leaky Check Valve Plug in Hydraulic Systems MikePhua 0 3 5 hours ago
Last Post: MikePhua
  Flushing Hydraulic Systems Is More Than Just Changing Fluid MikePhua 0 1 5 hours ago
Last Post: MikePhua
  Why Hitachi Dash-6 Excavators Struggle to Start After Fuel Filter Replacement MikePhua 0 3 6 hours ago
Last Post: MikePhua
  Why Does the Case 1845C Skid Steer Lose Drive Power When Warm Unless Lowering the Bucket? MikePhua 0 1 6 hours ago
Last Post: MikePhua
  Troubleshooting Transmission Pump Failures in Caterpillar 955L MikePhua 0 1 6 hours ago
Last Post: MikePhua
  Hitachi EX60URG Two-Sided Pump: Troubleshooting and Solutions MikePhua 0 1 6 hours ago
Last Post: MikePhua
  Diagnosing and Resolving Transmission Pump Issues in the CAT D8L Dozer MikePhua 0 1 6 hours ago
Last Post: MikePhua
  Kubota KX030 Hydraulic Problems: Diagnosis and Solutions MikePhua 0 1 6 hours ago
Last Post: MikePhua
  Diagnosing Drive Failure on Genie Z-45/22 Boom Lift MikePhua 0 2 6 hours ago
Last Post: MikePhua
  Troubleshooting Hydraulic Issues in Kobelco SK035 Mini Excavator MikePhua 0 1 6 hours ago
Last Post: MikePhua
  Troubleshooting Hydraulic Legs on a Case 688P MikePhua 0 3 7 hours ago
Last Post: MikePhua

Forum Jump:


Users browsing this thread: 1 Guest(s)