Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Hydrostatic Creep in the John Deere 750C Dozer: Diagnosing PCP Imbalance and Restoring Track Control
#1
Introduction: When One Track Has a Mind of Its Own
The John Deere 750C dozer is a hydrostatically driven crawler built for precision grading and earthmoving. But when one track begins to creep forward—even with the parking brake released—it signals a deeper issue within the hydrostatic control system. In this case, a persistent right-track creep led to a detailed investigation involving pump flushing, manual overrides, and pressure differential testing. This article breaks down the problem, explains the technical components involved, and offers a step-by-step guide to diagnosing and resolving hydrostatic imbalance.
Symptoms of the Problem
  • Right track creeps forward when the park lever is released.
  • Left track remains stationary under the same conditions.
  • During forward travel, pressing the decelerator stops the left track but not the right.
  • In reverse, the right track creeps backward while the left stops.
  • Fault code F629 (left track mistrack) appears intermittently.
These symptoms suggest an imbalance in hydraulic control between the left and right drive systems, likely originating from the hydrostatic pump’s internal control mechanisms.
Understanding the Hydrostatic Drive System
The 750C uses a dual hydrostatic pump system to independently control each track. Each pump is equipped with a Pressure Control Pilot (PCP), which regulates flow and pressure based on operator input and system feedback.
Key components include:
  • Hydrostatic Pumps: Deliver pressurized fluid to each track motor.
  • PCP (Pressure Control Pilot): Modulates pump output based on internal pressure settings.
  • Manual Override Levers: Allow direct mechanical control for testing.
  • Electronic Control Module (ECM): Coordinates signals and monitors fault codes.
  • Differential Pressure (ΔP): The difference in pressure between two control ports, used to detect imbalance.
Initial Diagnostic Steps
  1. Hydrostatic Pump Flush
    • Performed to remove contamination and reset internal flow paths.
    • No improvement observed, indicating the issue was not due to debris.
  2. Manual Override Testing
    • Actuating the pump PCP levers allowed both tracks to move correctly.
    • Actuating motor PCP levers had no effect, confirming the issue was upstream.
  3. PCP Internal Pressure Test
  • A differential pressure test revealed a 40 psi delta on the front pump PCP.
  • This exceeded the acceptable range of 0–5 psi, confirming a faulty PCP.
Building a DIY Differential Pressure Gauge
Due to limited access to specialized tools, a custom gauge setup was built:
  • Tee fitting with a center-mounted 0–300 psi gauge.
  • Ball valves on each side connected to test ports.
  • Alternating valve operation allowed pressure readings from each port.
  • Delta pressure calculated by subtracting one reading from the other.
This setup provided accurate diagnostics without expensive equipment.
Repair and Calibration
  • A new front pump PCP was ordered ($1,216 before tax).
  • After installation, the pump was re-nulled and recalibrated.
  • The right track creep was resolved, confirming the PCP as the root cause.
Exploring the F629 Fault Code
The F629 code indicates a mistrack condition on the left side. While not directly caused by the faulty right-side PCP, the imbalance may have contributed to inconsistent tracking behavior. Once the PCP was replaced, further diagnostics were planned to address the fault code.
Field Anecdote: The Indiana Farm Fix
A mechanic in Indiana recalled a similar issue on a 750C used for clearing fence rows. After months of chasing electrical faults, he discovered a 35 psi delta in the left pump PCP. Replacing the PCP restored full control and eliminated erratic track behavior. He now keeps a custom gauge kit in his service truck for on-site diagnostics.
Preventive Maintenance Tips
  • Inspect PCP pressures annually or every 1,000 hours.
  • Flush hydrostatic pumps during major service intervals.
  • Keep a record of fault codes and operating conditions.
  • Use high-quality hydraulic fluid and filters to reduce contamination.
  • Train operators to report subtle changes in track behavior early.
Conclusion: Precision in Pressure Restores Control
Hydrostatic systems rely on finely tuned pressure balances to deliver smooth, responsive control. When a PCP fails, even slightly, it can cause persistent creep, erratic movement, and fault codes that mask the true issue. By understanding the mechanics of differential pressure and using creative diagnostic tools, operators and technicians can restore performance and avoid costly downtime. In the world of dozers, control isn’t just about power—it’s about balance.
Reply


Possibly Related Threads…
Thread Author Replies Views Last Post
  Diagnosing and Fixing Exhaust Popping Sounds on a 48A MikePhua 0 11 7 hours ago
Last Post: MikePhua
  ChatGPT said: Troubleshooting John Deere 210LE 4x4 Not Engaging MikePhua 0 10 8 hours ago
Last Post: MikePhua
  Restoring a forgotten crane hidden in the briars MikePhua 0 11 8 hours ago
Last Post: MikePhua
  Removing a Link from a Track Chain on a Case 450 Dozer MikePhua 0 9 8 hours ago
Last Post: MikePhua
  John Deere 350C Weak in Reverse MikePhua 0 7 8 hours ago
Last Post: MikePhua
  Diagnosing low power in a 1999 Mack RD688S with E7 VMAC III system MikePhua 0 11 8 hours ago
Last Post: MikePhua
  Caterpillar D3G hydrostatic transmission sluggishness and diagnostic approach MikePhua 0 10 8 hours ago
Last Post: MikePhua
  International TD-20B Dozer and DT-429 Engine Push Rod Replacement MikePhua 0 11 Yesterday, 04:18 PM
Last Post: MikePhua
  Diagnosing Control Lag in the Simon 32' All-Terrain Scissor Lift MikePhua 0 13 Yesterday, 03:20 PM
Last Post: MikePhua
  Reviving the John Deere 992ELC Excavator: A Comprehensive Guide MikePhua 0 10 Yesterday, 03:14 PM
Last Post: MikePhua
  Komatsu D37 Track Tension Loss and Adjuster Cylinder Repair MikePhua 0 10 Yesterday, 03:13 PM
Last Post: MikePhua
  John Deere 690DR Excavator Right-Side Propel Issue MikePhua 0 11 Yesterday, 03:13 PM
Last Post: MikePhua
  Cold Weather Starting Problems in the John Deere 270 Skid Steer MikePhua 0 11 Yesterday, 03:12 PM
Last Post: MikePhua
  Diagnosing and Resolving Engine Knock in JCB 1550 Backhoes MikePhua 0 7 Yesterday, 03:06 PM
Last Post: MikePhua
  Restoring Winch Controls on the Allis-Chalmers 653 with Model 400 Winch MikePhua 0 8 Yesterday, 02:58 PM
Last Post: MikePhua

Forum Jump:


Users browsing this thread: